User Tools
tech:1936_ford_panel_truck
Differences
This shows you the differences between two versions of the page.
| Both sides previous revision Previous revision Next revision | Previous revision Last revision Both sides next revision | ||
|
tech:1936_ford_panel_truck [2019/01/05 02:44] reb [I NEED TO FIND OUT] |
tech:1936_ford_panel_truck [2019/01/11 06:02] reb |
||
|---|---|---|---|
| Line 1: | Line 1: | ||
| - | {{ :tech:tech-vehicle-ford-1_1.jpg?nolink&700x241 |Ford-Fun.com logo by Royce Barber using 3D-Coat sculpting app.}} | + | Ford-Fun.com is part of Royce E. Barber's website ONTU.org |
| - | ====== Ford-Fun.com is part of Royce E. Barber's website ONTU.org ====== | + | {{ :tech:tech-vehicle-ford-header-small.gif?nolink&500x172 }}.{{:tech:tech-vehicle-ford-3.jpg?direct&1200x947|Royce E. Barber's 1936 Ford Panel Truck}} |
| - | + | ||
| - | . | + | |
| - | + | ||
| - | ====== Updated on Jan-4-2019. ====== | + | |
| - | + | ||
| - | {{:tech:tech-vehicle-ford-3.jpg?direct&1200x947|Royce E. Barber's 1936 Ford Panel Truck}} | + | |
| . | . | ||
| Line 28: | Line 22: | ||
| * Steering wheel is "Grant Mahogany GT Steering Wheel", 14" Diameter, 3" Dish, hand-rubbed Mahogany Finger Grip, 4-Spoke Anodized Aluminum in Satin Silver finish. 15.8 x 14.9 x 2.5 inches. GRANT part # 724. Worth about $200.00 in 2019. Has Grant 3196 Installation Kit. | * Steering wheel is "Grant Mahogany GT Steering Wheel", 14" Diameter, 3" Dish, hand-rubbed Mahogany Finger Grip, 4-Spoke Anodized Aluminum in Satin Silver finish. 15.8 x 14.9 x 2.5 inches. GRANT part # 724. Worth about $200.00 in 2019. Has Grant 3196 Installation Kit. | ||
| - | * Manufacturer: Ford Motor Co. of Detroit | + | * Manufacturer: Ford Motor Co. of Detroit. |
| * Exact date manufactured: 1936. | * Exact date manufactured: 1936. | ||
| Line 55: | Line 49: | ||
| * Battery location is typical, in front of passenger seat, under a floor hatch. With attached trickle charger. | * Battery location is typical, in front of passenger seat, under a floor hatch. With attached trickle charger. | ||
| + | |||
| + | * Electric horn information; Schwarze M-68, Adrian Mich, Made in USA. | ||
| + | |||
| + | * Oil Filter is WIX 51061 with Barcode 7-65809-50061-7 Made in USA. Spin-on. | ||
| + | |||
| + | * The suspension spring is labeled, PJ04N1B, Made in USA, This End Down. | ||
| + | |||
| + | * The Distributor Cap is red, from Mallory Ignition, Part Number 8548201. | ||
| + | |||
| + | * The Flexplate "Flywheel" is labeled MD8, 48 1k1. It's missing it's dust cover. | ||
| + | |||
| + | * The AC Compressor is labeled; SD-508. Unknown serial number. Oil Suniso-5GS. Refrigerant 12. Sanyko Electric CO LTD. | ||
| + | |||
| + | * Headlamp Housing is labeled MAXTEL H4 JF. Bulb size? Does it come in white LED? | ||
| + | |||
| + | * Power Steering Pump is labeled: Remanufactured in the USA by Atsco Products Inc of Pheonix, AZ. | ||
| + | |||
| + | * Radiator brand unknown, but it looks like: ALLOYWORKS 3 Row Core Full Aluminum Radiator for Jeep Wrangler (as seen on Amazon website). | ||
| . | . | ||
| Line 67: | Line 79: | ||
| . | . | ||
| + | |||
| + | {{:tech:question-icon.gif?nolink&30x65}} | ||
| ====== I NEED TO FIND OUT ====== | ====== I NEED TO FIND OUT ====== | ||
| Line 76: | Line 90: | ||
| * Do I need an Oil Temp Gauge? I have an Oil Pressure Gauge.\\ | * Do I need an Oil Temp Gauge? I have an Oil Pressure Gauge.\\ | ||
| * Why does my carb pressure gauge flicker intensely, weak valve springs? Do I have a vacuum leak, perhaps a rough idle vacuum leak?\\ | * Why does my carb pressure gauge flicker intensely, weak valve springs? Do I have a vacuum leak, perhaps a rough idle vacuum leak?\\ | ||
| - | * When facing downhill, why is the parking gear stubborn.\\ | + | * Why is the parking gear extremely stubborn.\\ |
| - | * What carriage parts are safe to paint, to keep away rust.\\ | + | * What carriage parts are safe to paint, to keep away rust. |
| - | * Do I have rubber boot joints on my steering?\\ | + | |
| + | * What engine parts get hot? I assume the engine block and exhaust tubes and oil filter. \\ | ||
| + | * Do I have rubber boot joints on my steering? I don't think so. \\ | ||
| * Are there any electrical shorts at all anywhere. Are all severed wires capped off.\\ | * Are there any electrical shorts at all anywhere. Are all severed wires capped off.\\ | ||
| * Are all bolts tight?\\ | * Are all bolts tight?\\ | ||
| Line 98: | Line 114: | ||
| . | . | ||
| - | {{ :tech:1936-a.jpg?nolink&63x63 |1936-a.jpg}} | + | {{:tech:1936-time-icon.gif?nolink&104x145}} |
| - | + | ||
| - | + | ||
| - | ====== :tech:1936-icon.gif?nolink&150x150 ====== | + | |
| ====== Royce's Timeline of Events ====== | ====== Royce's Timeline of Events ====== | ||
| Line 127: | Line 140: | ||
| . | . | ||
| + | {{:tech:1936-icon.gif?nolink&150x150}} | ||
| ====== QUICK MANUAL ====== | ====== QUICK MANUAL ====== | ||
| - | * Features on the steering wheel and column: Tilt steering wheel. Longest is the gear shifter. Key. Turn indicator. The tiny screw is the emergency blinkers, push it in hard. \\ | + | * Features on the steering wheel and column: Tilt steering wheel. Longest is the gear shifter. Key. Turn indicator. The tiny screw is the emergency blinkers, push it in hard.\\ |
| - | * Inside the rear left door is a round key hole, which opens the driver door. Inside above the driver and passenger door are buttons to open those doors. The front two doors have no external handles, but a remote control is easy to install. \\ | + | * Inside the rear left door is a round key hole, which opens the driver door. Inside above the driver and passenger door are buttons to open those doors. The front two doors have no external handles, but a remote control is easy to install.\\ |
| * On the dash is a B&M Transmission slider, it's not needed and is disconnected.\\ | * On the dash is a B&M Transmission slider, it's not needed and is disconnected.\\ | ||
| - | * Many panels are on a hinge, including the ceiling toggle switches and lid of the center console, and on the side of the center console, and the wall immediately behind the passenger seat. \\ | + | * Many panels are on a hinge, including the ceiling toggle switches and lid of the center console, and on the side of the center console, and the wall immediately behind the passenger seat.\\ |
| - | * The little push button on the drivers floor is a standard Light Dimmer button. \\ | + | * The little push button on the drivers floor is a standard Light Dimmer button.\\ |
| - | * Outside decorative spare tire, has a release key hole under the center cap. The center cap is on a hinge, pry it forward. \\ | + | * Outside decorative spare tire, has a release key hole under the center cap. The center cap is on a hinge, pry it forward.\\ |
| * Engine bay opens by firmly pressing downward on the chrome handles, then pulling outward. | * Engine bay opens by firmly pressing downward on the chrome handles, then pulling outward. | ||
| Line 168: | Line 182: | ||
| {{ :tech:1936-b.jpg?nolink&200x102 |1936-b.jpg}} | {{ :tech:1936-b.jpg?nolink&200x102 |1936-b.jpg}} | ||
| - | ====== Eventual Projects and Repairs ====== | + | ====== Eventual Projects and Repairs ====== |
| - | * Crack in passenger window. Windows roll down slow after being in the paint shop in mid Dec 2018. Insert a modular back seat. I have a digital compass ready to install. I'm organizing all data/paperwork I can get on the truck, into a sturdy case with other 1936 memorabilia. Adding a matching wood steering wheel spinner. Will put UV coating to protect tires from sun/moisture/air/etc. Designing an aluminum toolbox for the inside, but am using a gold travel luggage for now to store tools and camping supplies. I don't yet know how to fix the horn. I notice slight rust on the front bumper so I want to have it thoroughly sand blasted and re-chromed. The inside of the rear doors need wood paneling or to be painted rootbeer brown. LowJack is $600.00 so I'm seeking a live DIY tracking solution such as a old iPhone. The following is a toolbox I designed in 3D-Coat. | + | * Crack in passenger window. Windows roll down slow after being in the paint shop in mid Dec 2018. Insert a modular back seat. I have a digital compass ready to install. I'm organizing all data/paperwork I can get on the truck, into a sturdy case with other 1936 memorabilia. Adding a matching wood steering wheel spinner. Will put UV coating to protect tires from sun/moisture/air/etc. Designing an aluminum toolbox for the inside, but am using a gold travel luggage for now to store tools and camping supplies. I don't yet know how to fix the horn. I notice slight rust on the front bumper so I want to have it thoroughly sand blasted and re-chromed. The inside of the rear doors need wood paneling or to be painted rootbeer brown. LowJack is $600.00 so I'm seeking a live DIY tracking solution such as a old iPhone. The following is a toolbox I designed in 3D-Coat, I may add a seat cushion to the top and a simple back rest. |
| {{ :tech:1936-toolbox-b.jpg?nolink&800x257 |Concept Truck Toolbox}} | {{ :tech:1936-toolbox-b.jpg?nolink&800x257 |Concept Truck Toolbox}} | ||
| Line 186: | Line 200: | ||
| . | . | ||
| - | {{ :tech:time-hourglass-icon.gif?nolink&72x150 }} | + | {{:tech:1936-a.jpg?nolink&63x63|1936-a.jpg}} |
| ===== Major World Events of 1936 ===== | ===== Major World Events of 1936 ===== | ||
| Line 228: | Line 241: | ||
| . | . | ||
| - | {{ :tech:1936-footer1.jpg?nolink&300x187 |1936-footer1.jpg}}Public comments, no login needed. I'll approve all nice comments. :) | + | . |
| + | |||
| + | . | ||
| + | |||
| + | {{:tech:1936-footer1.jpg?nolink&300x187|1936-footer1.jpg}} | ||
| + | |||
| + | ====== TRUCK HUMOR ====== | ||
| + | |||
| + | * Tubeless is our latest technology, it was a tireless effort.\\ | ||
| + | * If you got it, a trucker brought it.\\ | ||
| + | * A UPS truck hit the Microsoft building, they named it HotMail. That name was on fire. I was semi amused. It was the torque of the town.\\ | ||
| + | * I couldn't figure out the seatbelt, then it hit me, then it clicked, then I buckled up for another try.\\ | ||
| + | * What has four wheels and 'flys'? A garbage truck.\\ | ||
| + | * If you had a time traveling truck, do you travel from 'time to time' or put the breaks on that idea.\\ | ||
| + | * Chevy is Like a Rock, it just sits there for all time.\\ | ||
| + | * What car is a dog weary of? 'Vets.\\ | ||
| + | * I drove my truck today, as the motorcycle was 'two tired'.\\ | ||
| + | * I own a unicycle, it was a truck until I popped three wheelies. | ||
| + | |||
| + | . | ||
| + | |||
| + | . | ||
| + | |||
| + | . | ||
| + | |||
| + | Public comments, no login needed. I'll approve honorable comments. | ||
tech/1936_ford_panel_truck.txt · Last modified: 2019/01/16 07:48 by reb
Page Tools
